The pontoon furniture page this metro needed
Pontoons are what central Arkansas actually boats, and pontoon furniture is what Arkansas sun actually destroys. Laybacks, loungers, helm chairs and corner benches rebuild at your dock for $600 to $1,200 per major piece on the published guide, with full sets at $2,500 to $6,000 and piece-by-piece pricing that keeps the shaded furniture with years left off your invoice. The boat stays on its lift the whole time, which on a pontoon is the entire argument.
How pontoon furniture actually fails
In order: the sun side first, the seams before the panels and the bases last but worst. South and west facing pieces on a dock-kept boat can crack years before their shaded twins, seams split where thread and needle holes concentrate ultraviolet damage, and the wood-framed bases under older furniture quietly drink water at the deck line until staples have nothing left to hold. Our first-visit routine checks all three layers, because new vinyl over rotten framing is the oldest wasted money in this trade.
Foam sits in the middle of that story. Pontoon cushions that sat out storms or wintered under leaky covers carry waterlogged foam that molds new vinyl from underneath, and the squeeze test on every piece decides whether the $50 to $150 per-cushion foam line joins the quote. Skipping wet foam to save a few hundred dollars books the same job again in two seasons, and we would rather tell you that at the dock than apologize for it later.
Rebuilt for the next decade
Everything we build for pontoons assumes dock life: marine vinyl with UV inhibitors, thread rated for a decade of sun, closed-cell foam where water exposure demands it and drain-aware construction so cushions shed rain instead of storing it. Matching matters too, since half our pontoon work replaces the failed half of a set, and new pieces that match the survivors on color and grain are what make partial replacement look like a plan rather than a patch. North Little Rock Boat Upholstery brings the sample books to your dock so the match gets approved in daylight.
Pontoon questions, answered
Can pontoon seats be redone without replacing the whole furniture set?
Yes, and it is usually the right call. Pontoon furniture wears by sun exposure, so the laybacks and the helm seat typically fail years before the shaded benches. We price by the piece, $600 to $1,200 for laybacks and loungers, match the new vinyl to the survivors and leave sound furniture alone.
Re-cover my existing furniture or buy replacement furniture, which wins?
Re-covering wins when the bases and frames are sound, because you keep furniture that fits your deck layout for roughly half the cost of comparable new sets. Replacement wins when bases have rotted or the plastic has broken structurally. The base check on our first visit answers it honestly, piece by piece.
What causes pontoon vinyl to crack so much faster than car seats?
Sun, plainly. A dock-kept pontoon takes direct ultraviolet all day plus the light bouncing up off water and aluminum deck, with no garage in its life. Marine vinyl with UV inhibitors and UV-rated thread exists exactly for this duty, and it is what every piece we build carries.
How long does a full pontoon set take?
One patterning visit at the dock, two to four weeks of bench work in season and a fitting visit to install. Off-season the bench time shortens and the price drops by the published winter discount, which is why October is the smart month for set work.
Wondering how the dock visits actually work? The dock-side service page walks the whole sequence, patterning to fitting.
Price the pieces that actually failed
Photos of the furniture get a piece-by-piece quote off the public table, and the pontoon never leaves the lift.